Study on the Detoxification of Asbestos-Containing Wastes (ACW) Using SiC Plate

Myung Hwan Hong; Hyeok Mok Choi; So Young Joo; Chan Gi Lee; Jin-Ho Yoon

doi:10.7844/kirr.2020.29.1.35

All Issue

2020 Vol.29, Issue 1 Preview Page Next Page

Research Paper

Study on the Detoxification of Asbestos-Containing Wastes (ACW) Using SiC Plate SiC 플레이트를 이용한 석면 함유 폐기물의 무해화 연구

29 February 2020. pp. 35-42

PDF XML

Abstract

Even asbestos-containing waste (ACW) are highly harmful to humans, it continues being produced due to the massive disposal of asbestos-containing products. A development of asbestos detoxification and recycling technologies is required. Heat treatment using microwave is the most efficient method for ACW detoxification. However, microwave heat treatment method has the limitation that asbestos does not absorb microwave at room temperature. That is why, in this study, ACW was detoxified by microwave heat treatment adding the ACW between SiC plates, which are inorganic heating elements that absorb microwaves at room temperature. In order to improove the heat transfer, ACW was crushed and pulverized and then heated using microwave. Microwave heat treatment temperature and time variables were adjusted to investigate the detoxification properties according to heat treatment conditions. After heat treatment, treated ACW was analyzed for detoxification properties through crystal structure and microstructure analysis using X-ray diffraction (XRD) and scanning electron microscopy (SEM). Microwave heat treatment method using SiC plate can be heated up to the target temperature within a short time. Finally, complete asbestos detoxification was confirmed from the crystal structure and the microstructure when the microwave heat treatment was performed at 1,200°C for at over 60 minutes and at 1,300°C for at over 10 minutes.

Keywords

asbestos-containing wastes

microwave

SiC

detoxification

heat treatment

최근 인체 유해성이 높은 석면 함유 제품의 다량 폐기로 인해 석면 함유 폐기물(asbestos-containing waste: ACW)이 계속해서 발생하고 있으며, 매립지 부족 등의 이유로 석면 무해화 및 재활용 기술 개발이 요구되고 있다. 마이크로웨이브를 이용한 열처리는 석면 함유 폐기물 무해화에 가장 효율적인 방법이나 석면이 상온에서 마이크로웨이브를 흡수하지 않는 한계점을 가지고 있다. 본 연구에서는 상온에서 마이크로웨이브를 흡수하여 발열하는 무기 발열체인 SiC 플레이트 사이에 석면 함유 폐기물를 위치시킨 상태에서 마이크로웨이브 열처리를 진행하는 방법으로 석면 함유 폐기물를 무해화 하였다. 효율적인 열처리를 위하여 석면 함유 폐기물를 파쇄 및 분쇄 공정을 통해 분말화하여 무해화 열처리 실험을 진행 하였으며, 열처리 조건에 따른 무해화 특성을 파악하기 위하여 마이크로웨이브 열처리 온도와 시간 변수를 조절하였다. 열처리 후 석면 함유 폐기물는 XRD와 SEM을 이용한 결정구조 및 미세구조 분석을 통하여 무해화 특성을 분석 하였다. SiC 플레이트를 적용한 마이크로웨이브 열처리 방법은 단시간 내에 목표 온도까지 가열이 가능하며 최종적으로 1,200°C에서는 60 분 이상, 1,300°C에서는 10 분 이상의 마이크로웨이브 열처리를 진행하였을 때 결정구조와 미세구조상에서 석면이 완전히 제거되는 것을 확인하였다.

키워드

석면 함유 폐기물

마이크로웨이브

SiC

무해화

열처리

References

Leonelli, C., Veronesi, P., Boccaccini, D. N., et al., 2006 : Microwave thermal inertisation of asbestos containing waste and its recycling in traditional ceramics, J. Hazard. Mater., 135(1-3), pp.149-155.

10.1016/j.jhazmat.2005.11.03516406335

Skinner, H. C. W., 2003 : Mineralogy of asbestos minerals, Indoor Built Environ., 12(6), pp.385-389.

10.1177/1420326X03037003

Donaldson, K., Tran, C. L., 2004 : An introduction to the short-term toxicology of respirable industrial fibres, Mutat. Res. Fundam. Mol. Mech. Mutagen., 553(1-2), pp.5-9.

10.1016/j.mrfmmm.2004.06.01115288528

Kusiorowski, R., Zaremba, T., Piotrowski, J., et al., 2012 : Thermal decomposition of different types of asbestos, J. Therm. Anal. Calorim., 109(2), pp.693-704.

10.1007/s10973-012-2222-9

Gualtieri, A. F., Tartaglia, A., 2000 : Thermal decomposition of asbestos and recycling in traditional ceramics, J. Eur. Ceram. Soc., 20(9), pp.1409-1418.

10.1016/S0955-2219(99)00290-3

Wagner, J. C., Sleggs, C. A., and Marchand, P., 1960 : Diffuse pleural mesothelioma and asbestos exposure in the North Western Cape Province, Occup. Environ. Med., 17(4), pp.260-271.

10.1136/oem.17.4.26013782506PMC1038078

Newhouse, M. L., Thompson, H., 1965 : Mesothelioma of pleura and peritoneum following exposure to asbestos in the London area, Occup. Environ. Med., 22(4), pp.261- 269.

10.1136/oem.22.4.2615836565PMC1069377

Selikoff, I. J., Hammond, E. C., 1968 : Environmental epidemiology. 3. Community effects of nonoccupational environmental asbestos exposure, Am. J. Public Health Nations Health, 58(9), pp.1658-1666.

10.2105/AJPH.58.9.16585692054PMC1228874

Turci, F., Colonna, M., Tomatis, M., et al., 2010 : New detoxification processes for asbestos fibers in the environment, J. Toxicol. Environ. Health, Part A, 73(5-6), pp.368- 377.

10.1080/1528739090344267820155579

Werner, A. J., Hochella, M. F., Guthrie, G. D., et al., 1995 : Asbestiform riebeckite (crocidolite) dissolution in the presence of Fe chelators: implications for mineral-induced disease, Am. Mineral., 80(11-12), pp.1093-1103.

10.2138/am-1995-11-1201

Block, J., Petrakis, L., Dolhert, L. E., et al., 2000 : A novel approach for the in-situ chemical elimination of chrysotile from asbestos-containing fireproofing materials, Environ. Sci. Technol., 34(11), pp.2293-2298.

10.1021/es990432d

Gomez, E., Rani, D. A., Cheeseman, C. R., et al., 2009 : Thermal plasma technology for the treatment of wastes: a critical review, J. Hazard. Mater., 161(2-3), pp.614-626.

10.1016/j.jhazmat.2008.04.01718499345

Gualtieri, A. F., Cavenati, C., Zanatto, I., et al., 2008 : The transformation sequence of cement-asbestos slates up to 1200°C and safe recycling of the reaction product in stoneware tile mixtures, J. Hazard. Mater., 152(2), pp.563- 570.

10.1016/j.jhazmat.2007.07.03717709183

Jolicoeur, C., Duchesne, D., 1981 : Infrared and thermogravimetric studies of the thermal degradation of chrysotile asbestos fibers: evidence for matrix effects, Can. J. Chem., 59(10), pp.1521-1526.

10.1139/v81-223

Kashimura, K., Yamaguchi, T., Sato, M., et al., 2014 : Rapid transformation of asbestos into harmless waste by a microwave rotary furnace: application of microwave heating to rubble processing of the 2011 Tohoku earthquake, J. Hazard. Toxic. Radioact. Waste, 19(3), pp.04014041.

10.1061/(ASCE)HZ.2153-5515.0000249

Borderes, A., 2000 : Vitrification of the incineration residues, Verre-Paris Then Versailles-, 6(4), pp.19-21.

Jianmiao, D., Shizong, L., 2005 : Effect of microwave processing on aluminate cement clinkering, J. Wuhan Univ. Technol., Mater. Sci. Ed., 20(2), pp.77-79.

10.1007/BF02838495

Clark, D. E., Sutton, W. H., 1996 : Microwave processing of materials, Annu. Rev. Mater. Sci., 26(1), pp.299-331.

10.1146/annurev.ms.26.080196.001503

Kozawa, T., Onda, A., Yanagisawa, K., et al., 2010 : Thermal decomposition of chrysotile-containing wastes in a water vapor atmosphere, J. Ceram. Soc. Jpn., 118(1384), pp. 1199-1201.

10.2109/jcersj2.118.1199

Information

Publisher :The Korean Institute of Resources Recycling
Publisher(Ko) :한국자원리싸이클링학회
Journal Title :Journal of the Korean Institute of Resources Recycling
Journal Title(Ko) :자원리싸이클링
Volume : 29
No :1
Pages :35-42
Received Date : 2019-11-27
Revised Date : 2020-01-29
Accepted Date : 2020-02-05
DOI :https://doi.org/10.7844/kirr.2020.29.1.35

Resources Recycling ISSN:2765-3439(Print) 2765-3447(Online) 자원리싸이클링

All Issue